Серия DC-DC модульных преобразователей TSR1

TRACO

Общие характеристики

 Раздел DC-DC модульные преобразователи
Монтаж
Количество каналов
Ток 1 выхода
Уровень пульсаций
Напряжение изоляции вход-выход
Сертификаты медицинские

Документация на серию TSR1

Baar, 11. December 2014 Cleaning Guideline Scope This guideline covers hermetically sealed board mounted Traco converters. We do not recommend washing insert moulded products, where it is difficult to get them dry inside. Please check also, if there is an additional comment about washing in the datasheet or application note of the concerned product. Note: We do generally not recommend washing or cleaning electronic components. You should avoid it, if it is not absolutely necessary. It may reduce the reliability of the involved components in your application. Board cooling prior to cleaning process Converters and their associated application PCB assemblies should not be wash-cleaned after soldering until they had the opportunity to cool within the cleaning solution temperature. This will prevent vacuum absorption of the cleaning liquid into the module between the pins and the potting during cooling. Cleaning agents Cleaning method Classification Cleaning agents Water type Deionized water Ultrasonic wave Solvent type IPA Note: In general, the liquid temperature shall be less than 60°C. Cleaning process In aqueous cleaning, it is preferred to have an in-line cleaner system consisting of several cleaning stages (prewash, wash, rinse, final rinse, and drying). Deionised (DI) water is recommended for aqueous cleaning; the minimum resistively level is 1MΩ-cm. Tap-water quality varies per region in terms of hardness, chloride, and solid contents. Therefore, the use of tap water is not recommended for aqueous cleaning. Note: The total time of ultrasonic wave shall be less than 3 minutes. Drying After cleaning, assure that everything will be dry enough, that the moisture and other potential contaminants will not be present anymore. Use an air circulating chamber (e.g. 0.5-0.7m3/s) and thermal oven at 80-100°C (during 20-120min, depending on assembling, structure, components). Handheld air guns are not recommended. It is on customer’s own responsibility to ensure all components are dry. Product post-wash external appearance The marking or date-code may fade or disappear after cleaning. That does not concern the performance of the converter. Andreas Flühler, Head of Technical Services PDF
Рекомендации по промывке и сушке 

Cleaning Guideline

Дата модификации: 02.02.2021

Размер: 79 Кб

1 стр.

Non-Isolated DC/DC Converter (POL) • Up to 96% efficiency – No heat-sink required • Pin compatible with LMxx linear regulators • SIP-package fits existing TO-220 footprint • • • • • • • Built in filter capacitors Operation temp. range –40°C to +85°C Short circuit protection Wide input operating range Excellent line / load regulation TSR 1 Series, 1 A The TSR 1 series step-down switching regulators are drop-in replacement for inefficient 78xx linear regulators. A high efficiency up to 96% allows full load operation up to +60°C ambient temperature without the need of any heat-sink or forced cooling. The TSR 1 switching regulators provide other significant features over linear regulators, i.e. better output accuracy (±2%), lower standby current of 2 mA and no requirement of external capacitors. The high efficiency and low standby power consumption makes these regulators an ideal solution for many battery powered applications. Low standby current 3-year product warranty Models Order Code Output Current max. Input Voltage Range Output Voltage nom. Efficiency typ. 1.2 VDC 74 % (at Vin min.) 1.5 VDC 78 % (at Vin min.) 1.8 VDC 82 % (at Vin min.) 2.5 VDC 87 % (at Vin min.) 4.75 - 36 VDC (9 VDC nom.) 3.3 VDC 91 % (at Vin min.) 6.5 - 36 VDC (12 VDC nom.) 5 VDC 94 % (at Vin min.) TSR 1-2465 9 - 36 VDC (12 VDC nom.) 6.5 VDC 93 % (at Vin min.) TSR 1-2490 12 - 36 VDC (24 VDC nom.) 9 VDC 95 % (at Vin min.) TSR 1-24120 15 - 36 VDC (24 VDC nom.) 12 VDC 95 % (at Vin min.) TSR 1-24150 18 - 36 VDC (24 VDC nom.) 15 VDC 96 % (at Vin min.) TSR 1-2412 TSR 1-2415 4.6 - 36 VDC (9 VDC nom.) TSR 1-2418 TSR 1-2425 TSR 1-2433 TSR 1-2450 Note 1'000 mA - For input voltage higher than 32 VDC an external input capacitor (22 µF) is required. www.tracopower.com April 27, 2020 Page 1 / 3 PDF
Документация на TSR 1-2412 

TSR 1 Datasheet 1 Amp POL switching regulator, 4.6 to -36 VDC input, pos.-pos. circuit, LM78 compatible, SIP-3

Дата модификации: 27.04.2020

Размер: 770.1 Кб

3 стр.

DC/DC Converters TSR-1 Series, 1 A Features ◆ Up to 96 % efficiency – No heat-sink required ◆ Pin compatible with LMxx linear regulators ◆ SIP-package fits existing TO-220 footprint ◆ Built in filter capacitors ◆ Operation temp. range –40°C to +85°C ◆ Short circuit protection ◆ Wide input operating range ◆ Excellent line / load regulation ◆ Low standby current ◆ 3-year product warranty The new TSR-1 series step-down switching regulators are drop-in replacement for inefficient 78xx linear regulators. A high efficiency up to 96 % allows full load operation up to +60°C ambient temperature without the need of any heat-sink or forced cooling. The TSR-1 switching regulators provide other significant features over linear regulators, i.e. better output accuracy (±2 %), lower standby current of 2 mA and no requirement of external capacitors. The high efficiency and low standby power consumption makes these regulators an ideal solution for many battery powered applications. Models Order code Input voltage range Output voltage Output current max. Efficiency typ. @ Vin min. @ Vin max. TSR 1-2412 4.6 – 36 VDC* 1.2 VDC 74 % 62 % TSR 1-2415 4.6 – 36 VDC* 1.5 VDC 78 % 65 % TSR 1-2418 4.6 – 36 VDC* 1.8 VDC 82 % 69 % TSR 1-2425 4.6 – 36 VDC* 2.5 VDC TSR 1-2433 4.75 – 36 VDC* 3.3 VDC TSR 1-2450 6.5 – 36 VDC* TSR 1-2465 87 % 75 % 91 % 78 % 5.0 VDC 94 % 84 % 9.0 – 36 VDC* 6.5 VDC 93 % 87 % 1.0 A TSR 1-2490 12 – 36 VDC* 9.0 VDC 95 % 90 % TSR 1-24120 15 – 36 VDC* 12 VDC 95 % 92 % TSR 1-24150 18 – 36 VDC* 15 VDC 96 % 94 % * For input voltage higher than 32 VDC an input capcitor 22 µF / 50 V is required. See application notes (page 3) http://www.tracopower.com Page 1 of 3 PDF
Документация на серию TSR1 

Дата модификации: 11.05.2012

Размер: 222.4 Кб

3 стр.

DC/DC Converters TSR-1 Series, 1 A Features ◆ Up to 96 % efficiency –> No heat-sink required ◆ Pin compatible with LMxx linear regulators ◆ SIP-package fits existing TO-220 footprint ◆ Built in filter capacitors ◆ Operation temp. range –40 to +85 °C ◆ Short circuit protection ◆ Wide input operating range ◆ Excellent line / load regulation ◆ Low standby current ◆ 3-year product warranty The new TSR-1 series step-down switching regulators are drop-in replacement for inefficient 78xx linear regulators. A high efficiency up to 96 % allows full load operation up to +60 °C ambient temperature without the need of any heat-sink or forced cooling. The TSR-1 switching regulators provide other significant features over linear regulators, i.e. better output accuracy (± 2 %), lower standby current of 2 mA and no requirement of external capacitors. The high efficiency and low standby power consumption makes these regulators an ideal solution for many battery powered applications. Models Order code Input voltage range Output voltage Output current max. Efficiency typ. @ Vin min. @ Vin max. TSR 1-2412 4.6 – 36 VDC* 1.2 VDC 74 % 62 % TSR 1-2415 4.6 – 36 VDC* 1.5 VDC 78 % 65 % TSR 1-2418 4.6 – 36 VDC* 1.8 VDC 82 % 69 % TSR 1-2425 4.6 – 36 VDC* 2.5 VDC TSR 1-2433 4.75 – 36 VDC* 3.3 VDC TSR 1-2450 6.5 – 36 VDC* TSR 1-2465 87 % 75 % 91 % 78 % 5.0 VDC 94 % 84 % 9.0 – 36 VDC* 6.5 VDC 93 % 87 % 1.0 A TSR 1-2490 12 – 36 VDC* 9.0 VDC 95 % 90 % TSR 1-24120 15 – 36 VDC* 12 VDC 95 % 92 % TSR 1-24150 18 – 36 VDC* 15 VDC 96 % 94 % * For input voltage higher than 32 VDC an input capcitor 22 µF / 50 V is required. See application notes (page 3) http://www.tracopower.com Page 1 of 3 PDF
Документация на серию TSR1 

Дата модификации: 27.02.2009

Размер: 206.5 Кб

3 стр.

    Товары серии TSR1

    Наименование i Упаковка P вых U вх Выход Возможности Защита U вх ном. U1 КПД Размер T раб Паралл. сх.
    TSR 1-2412 (TRACO)
     
    		DC-DC модульный преобразователь - Монтаж: на плату, SIP3; P вых: 1.5 Вт; #: 1; U вх: 4.... в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR 1-24120 (TRACO)
     
    		в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR 1-2415 (TRACO)
     
    		в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR 1-24150 (TRACO)
     
    		DC-DC модульный преобразователь - Монтаж: на плату, SIP3; P вых: 15 Вт; #: 1; U вх: 18.... в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR 1-2418 (TRACO)
     
    		DC-DC модульный преобразователь - Монтаж: на плату, SIP3; P вых: 1.8 Вт; #: 1; U вх: 4.... в линейках 10 шт 11.7×10.2×7.6 мм —
    TSR 1-2425 (TRACO)
     
    		DC-DC модульный преобразователь - Монтаж: на плату, SIP3; P вых: 2.5 Вт; #: 1; U вх: 4.... в линейках 10 шт 11.7×10.2×7.6 мм —
    TSR 1-2433 (TRACO)
     
    		в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR 1-2450 (TRACO)
     
    		в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR 1-2465 (TRACO)
     
    		AC-DC сетевой преобразователь - ; Примечание: CONVERTER, DC/DC, 24V/6.5V, 1A, SIP; DC /... в линейках 10 шт короткого замыкания, перегрева 11.7×7.6×10.2 мм —
    TSR 1-2490 (TRACO)
     
    		DC-DC в линейках 10 шт короткого замыкания, перегрева 11.7×10.2×7.6 мм —
    TSR1-2412 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 1.2W, Hybrid — — 11.7×7.6×10.7 мм
    TSR1-24120 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 12W, Hybrid — 11.7×7.6×10.7 мм
    TSR1-2415 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 2W, Hybrid — — 11.7×7.6×10.7 мм
    TSR1-24150 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 15W, Hybrid — — 11.7×7.6×10.7 мм
    TSR1-2418 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 2W, Hybrid — — 11.7×7.6×10.7 мм
    TSR1-2425 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 3W, Hybrid — 11.7×7.6×10.7 мм
    TSR1-2433 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 4W, Hybrid — 11.7×7.6×10.7 мм
    TSR1-2450 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 5W, Hybrid — — 11.7×7.6×10.7 мм
    TSR1-2465 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 7W, Hybrid — 11.7×7.6×10.7 мм
    TSR1-2490 (TRACO)
     
    		DC-DC Regulated Power Supply Module, 1 Output, 9W, Hybrid — — 11.7×7.6×10.7 мм

    TSR1 публикации

    15 апреля 2021
    новость

    TSR 1E и TSR 1.5E – недорогие высокоэффективные понижающие стабилизаторы (POL) от TRACO

    Компания TRACO обновила семейство понижающих стабилизаторов TSR, выпустив две новые серии TSR1E и TSR1.5E с максимальным выходным током 1 и 1,5 А, соответственно. Основной особенностью новых стабилизаторов является пониженная стоимость при... ...читать